Study Finds Levels of Hydrogen Sulfide ‘Off the Scales’ in Central Texas
The first readings Abigail Edgar took of hydrogen sulfide and methane at oilfields in Caldwell County in 2021 were so high that she thought her equipment was malfunctioning.
“It was off the scales. Methane was off the scales and hydrogen sulfide was off the scales,” said Edgar, a master’s student in geography at Texas State University. “The monitor would immediately start beeping when I crossed the property line.”
Edgar was recording dangerous levels of hydrogen sulfide at wells on private property in Caldwell County, 30 miles southeast of Austin. Hydrogen sulfide is a toxic and highly flammable gas often found in oil and gas formations. During the course of her research, the gas was so potent at three separate wells that Edgar’s respirator did not provide enough protection and she had to leave for her safety.
Edgar teamed up with University of Cincinnati environmental scientist Amy Townsend-Small, an expert on methane, to take another round of measurements in 2023. They found the wells were directly releasing gas — including hydrogen sulfide and methane — into the atmosphere in a process called venting. Some of the wells venting gas were alongside public roads. Others were next to backyards and driveways.
In a paper published in Environmental Research Communications last week, Edgar, Townsend-Small and other authors at Texas State University and the University of Maryland report hydrogen sulfide readings at 46 wells around Caldwell County. Hydrogen sulfide concentrations at 13 of the wells were at least 300 parts per million (ppm) — the maximum reading on the measuring device. Eight other sites had readings over 100 ppm. Exposure to 100 ppm of hydrogen sulfide is immediately dangerous to life or health, according to the National Institute for Occupational Safety and Health. The study warns these hydrogen sulfide levels are a hazard for people living and working in the area.
“Here in Texas we rely heavily on the oil industry and protect the oil industry. And I think rightfully so,” Edgar said. “But there has to be something done for these neighbors. We’re slowly poisoning these communities.”
Oilfield companies are required to adopt protocols to protect workers from hydrogen sulfide. But the general public is often exposed to low-level concentrations. The gas can disperse for miles downwind, especially during cold weather. Symptoms of low to mid-level hydrogen sulfide exposure include headaches, nausea, coughing and nose and eye irritation. The gas is also present at landfills, wastewater treatment facilities and large animal feedlots.
State rules prohibit the waste of natural gas through venting and flaring except under certain circumstances. But researchers found that venting was commonplace in Caldwell County after the gas processing plant there closed down in 2017. Inside Climate News found that the Railroad Commission of Texas, which regulates oil and gas extraction, has not issued any recent exceptions for venting or flaring gas in the county.
The agency did not respond to questions about gas venting or hydrogen sulfide exposure in the area. Spokesperson Patty Ramon said, “Our rules, permitting and inspection systems are designed to protect public safety and the environment.”
The Texas Commission on Environmental Quality (TCEQ) regulates ambient concentrations of hydrogen sulfide. Agency spokesperson Richard Richter said that the measurements in the study cannot be used to evaluate the exposure to the general public. He said that in an unspecified number of TCEQ investigations in Caldwell County since 2017 the H2S concentrations in ambient air did not exceed state standards.
Production flatlined in the Luling oilfield
The railroad town of Luling in Caldwell County, about 50 miles south of Austin, boomed after Edgar B. Davis struck oil in 1922. Wells in the Luling oilfield cut diagonally across the county, dotting unincorporated areas like Stairtown and within the Luling city limits.
The oil patch was largely tapped out by the 1980s, but low-production wells keep pumping to this day. In June 2024, the most recent month with available data, operators in Caldwell County reported producing less than 71,000 barrels of oil. That places Caldwell at 63 out of 199 oil-producing counties in Texas that month.
Amid production declines, the Luling Oil Museum still invites visitors to learn about the town’s drilling heritage. The other main attraction in Luling, population 5,500, is the annual Watermelon Thump festival.
The Luling oilfield is one of many across Texas characterized by gas high in hydrogen sulfide.
The pungent “rotten egg” smell emanating from the Luling oil fields is so ubiquitous that local media outlets have dubbed it the “Luling effect.” People as far as Austin have called 911 to report the smell, which comes from hydrogen sulfide and other chemicals.
The Railroad Commission implements State Rule 36, requiring operators to report the hydrogen sulfide concentration at wells, determine the radius of exposure and report any accidental releases of hydrogen sulfide. Operators are required to install signs and restrict public access to sites with a risk of exposure.
Groundlevel hydrogen sulfide concentrations over 0.08 ppm, averaged over a 30-minute period, are prohibited by state law if the emissions affect residential or commercial property. In an investigation earlier this year, the Houston Chronicle and The Examination found that residents in the Permian Basin often report symptoms of hydrogen sulfide exposure, but state regulators rarely issue meaningful penalties to the companies responsible for the pollution.
When the TCEQ records elevated H2S levels in ambient air, the agency’s goal is to identify the source and ensure the emissions are stopped, its spokesperson said. He reiterated that because the study’s measurements were taken at the wellhead, the readings were not in violation of TCEQ standards.
Low producing oil wells, but high hydrogen sulfide emissions
Texas State University’s Edgar contacted landowners in Caldwell County to find sites to measure hydrogen sulfide and methane emissions.
Edgar said that the landowners were unaware that gas was being directly vented on their property. She said one resident had been asked by his doctor if he could be suffering hydrogen sulfide poisoning.
“They were happy to have somebody take notice of it,” she said.
The researchers selected 46 wells to study. The oldest had been drilled in the 1930s, but most were drilled in the 1960s through 1980s. All the wells are considered marginal, with less than 15 barrels of oil production a day. (In contrast, fracked wells in Texas can produce thousands of barrels a day.) The team took direct measurements from the wellhead using a Bascom-Turner Gas Rover and an Indaco Hi-Flow Sampler. Hydrogen sulfide was measured over a five-minute period.
The methane emissions measured at the wells were similar to previous studies of marginal oil wells. Hydrogen sulfide concentrations ranged from zero parts per million to at least 300 parts per million, the maximum reading on the Gas Rover.
Hydrogen sulfide can be immediately lethal at concentrations over 700 ppm. Exposure to more than 500 ppm will cause people to collapse within five minutes. An oilfield worker and his wife were killed by hydrogen sulfide exposure in Odessa in 2019.
Hydrogen sulfide dissipates and would be found in lower concentrations in public areas near the wells. While not as well understood as acute, high-level exposure, research shows that chronic, low-level hydrogen sulfide exposure also has health effects. One 2023 literature review of over 100 previous studies found that chronic community hydrogen sulfide exposure at average concentrations below 0.01 ppm has been associated with health effects including eye, nose, respiratory and neurological symptoms. The authors write that individuals with underlying health conditions such as asthma could be particularly at risk.
The University of Cincinnati’s Townsend-Small said the Caldwell County wells are deserving of study because of the anecdotal evidence of strong hydrogen sulfide smells and their proximity to large urban areas.
“These wells are so close to so many people,” she said. “And they are emitting a hazardous substance that could be affecting so many people.”
Townsend-Small said plugging the Caldwell County wells or capturing the gas is “low-hanging fruit” to reduce methane emissions and health effects of hydrogen sulfide without significant impacts to oil production.
Edgar said it is unclear whether the Railroad Commission or the TCEQ is responsible for regulating venting at oil wells when it contributes to air pollution. She said one simple step would be for Railroad Commission staff to record hydrogen sulfide levels when they make field visits in Caldwell County.
“I was not able to come up with any good answers to whose fault is this, who should fix it, and how it should be fixed,” she said.
She said her greatest concern is for oilfield workers and neighbors who live next door to wells.
“Part of being in the oilfields”
Luling city manager Mark Mayo said people coming through town often comment on the smell.
But Mayo, who grew up in the Permian Basin, is no stranger to the odor of sour gas. He said he didn’t think Luling residents are at risk from hydrogen sulfide.
“Just because it has a smell doesn’t mean it’s always bad,” he said. “That’s part of being in the oilfield.”
But he took note of discrepancies documented in the study. Researchers found that some wells listed as “active” with the Railroad Commission were no longer producing. Others listed as “inactive” or “plugged” were still producing. Mayo said the city relies on the agency to ensure oil companies are following state rules, including those for hydrogen sulfide.
“That’s the Railroad Commission’s place,” he said. “As far as the city, we don’t have the ability or the equipment to stay up on that.”
Air quality experts have long known that Caldwell County is a locus of hydrogen sulfide emissions. But there are no stationary hydrogen sulfide monitors to track community levels of exposure.
Neil Carman, the Lone Star Sierra Club’s clean air director, previously worked as an air pollution control inspector for the TCEQ. Carman said to prove that emissions exceed the TCEQ standards would require 30-minute readings, subtracting any contributions of hydrogen sulfide from upwind, instead of the five-minute measurements of the study. But he did not doubt that excess hydrogen sulfide is being released.
“Luling, Texas, there is a huge mess out there,” he said. “I’ve been through many times. I’d say almost every time I’d get a headache.”
Carman said that memory loss and insomnia are other frequent symptoms of exposure.
“It’s really unacceptable and outrageous to the people in these communities,” Carman said.
Sharon Wilson of the nonprofit Oilfield Witness has researched compliance with the Railroad Commission’s hydrogen sulfide rules. In a previous report, she found that many companies fail to submit the H9 form reporting the hydrogen sulfide level at wells.
“Texas has a gas problem. We have a hydrogen sulfide problem and it’s putting people at risk,” Wilson said. “We see the high levels of hydrogen sulfide from the few air monitors there are in the Permian Basin.”
Wilson travels the Texas oil fields measuring methane emissions with a thermal camera. She said often the hydrogen sulfide fumes are so overwhelming she can’t leave her vehicle.
“Texans are not receiving equal protection from oil and gas pollution,” she said. “We need more monitors in all areas of oil and gas activity.”
This article originally appeared in The Texas Tribune at https://www.texastribune.org/2024/09/20/texas-oil-wells-hydrogen-sulfide-caldwell-county/.
The Texas Tribune is a member-supported, nonpartisan newsroom informing and engaging Texans on state politics and policy. Learn more at texastribune.org.
Photo: A cow stands next to a non-producing oil well in Caldwell County. Gas has been venting out of the well even though it no longer produces oil. Credit: Courtesy of Abigail Edgar